ISSN   1004-0595

CN  62-1224/O4

高级检索
刘娟, 王帅, 游龙, 祝林, 张智源, 逄显娟, 杜三明, 王刚, 张永振. MoCoB金属陶瓷的摩擦配副行为及机理研究[J]. 摩擦学学报(中英文), 2025, 45(1): 1−12. DOI: 10.16078/j.tribology.2023204
引用本文: 刘娟, 王帅, 游龙, 祝林, 张智源, 逄显娟, 杜三明, 王刚, 张永振. MoCoB金属陶瓷的摩擦配副行为及机理研究[J]. 摩擦学学报(中英文), 2025, 45(1): 1−12. DOI: 10.16078/j.tribology.2023204
LIU Juan, WANG Shuai, YOU Long, ZHU Lin, ZHANG Zhiyuan, PANG Xianjuan, DU Sanming, WANG Gang, ZHANG Yongzhen. Tribological Properties of MoCoB Cermet Coupled with Different Counterparts Materials[J]. Tribology, 2025, 45(1): 1−12. DOI: 10.16078/j.tribology.2023204
Citation: LIU Juan, WANG Shuai, YOU Long, ZHU Lin, ZHANG Zhiyuan, PANG Xianjuan, DU Sanming, WANG Gang, ZHANG Yongzhen. Tribological Properties of MoCoB Cermet Coupled with Different Counterparts Materials[J]. Tribology, 2025, 45(1): 1−12. DOI: 10.16078/j.tribology.2023204

MoCoB金属陶瓷的摩擦配副行为及机理研究

Tribological Properties of MoCoB Cermet Coupled with Different Counterparts Materials

  • 摘要: 采用真空热压烧结方法成功制备了MoCoB金属陶瓷材料,系统研究了MoCoB金属陶瓷与4种不同摩擦对偶材料的摩擦学性能,并分析讨论了其摩擦磨损机制. 研究表明:所制备材料具有较好的致密性,相对密度为97.8%,维氏硬度高达16.4±0.2 GPa. 此外,研究发现对偶材料对MoCoB金属陶瓷的室温干摩擦性能有着显著的影响,当MoCoB与硬度较低的ZrO2配副时,磨痕和对偶表面都覆盖着大量的磨屑,磨损程度都比较严重,具有最高的摩擦系数(0.7)和磨损率(2.3×10–5 mm3/(N·m),主要磨损机制为二体磨粒磨损和黏着磨损. 当MoCoB与硬度相当的Al2O3配副时,MoCoB磨痕表面磨粒较少,摩擦表面覆盖着带有疲劳裂纹的摩擦膜并伴有剥落现象,主要磨损机制为黏着磨损. 而MoCoB与硬度相当的Si3N4配副对摩时,MoCoB金属陶瓷表现出最佳的耐磨性能,磨损率低至1.6×10–6 mm3/(N·m),对偶球表面可能形成了一层SiO2氧化层,可以起到耐磨效果,磨损机制以轻微磨粒磨损为主. 当MoCoB与硬度值较高的SiC对偶时,MoCoB磨损表面由于摩擦氧化作用生成的摩擦氧化膜能够起到润滑的作用,摩擦系数低至0.48.

     

    Abstract: Cermets have many potential applications in the field of wear-resistant structural materials, such as aerospace, equipment manufacturing and automotive, etc. MxMBx cermet (M and M represent different transition metal atoms, x=1,2) is a type of ternary transition metal boride, which consists of transition metal atomic layers and boron atomic layers alternately, forming a three-dimensional network structure connected by strong covalent bonds. This crystal structure gives the materials many excellent properties, such as high melting point, high toughness, high hardness and good thermal conductivity. In comparison, MoCoB cermet has lower sintering temperature and excellent mechanical properties, and can be successfully synthesized by vacuum liquid-phase sintering or SPS sintering. However, the investigation on the tribological properties when coupling with counterpart materials still needs to be further explored. In this study, dense MoCoB cermet material was successfully prepared by vacuum hot-press sintering method, in which the molar ratio of three elements powder was 1:1.25:1. The specimen was sintered at 1250 ℃ with a pressure of 30 MPa for 40 min, and finally cooled to room temperature in the furnace to obtain MoCoB cermet block material. The microstructure, mechanical properties of MoCoB cermet, and its tribological properties coupling with four different counterpart materials were investigated. The applied load, rotation radius and rotation speed during the friction test were 20 N, 4 mm and 300 r/min, respectively, and the test time was 30 min. The friction and wear mechanisms were systematically analyzed and discussed. It was concluded that the MoCoB cermet prepared by this sintering process was pure phase. The measured density and relative density of as prepared MoCoB specimen are about 8.7 g/cm3and 97.8%, respectively, indicating that the MoCoB specimen had a good densification. Its Vickers hardness was as high as 16.4±0.2 GPa, and the etched MoCoB cermet grains was lath-shaped with an average length of less than 10 μm. In addition, it was also confirmed that the tribological properties of MoCoB cermet were sensitive to the counterpart materials. The friction coefficient decreased with the increase of the hardness value of the counterpart materials, while the wear rate was not directly related to the hardness value of the counterpart materials. When MoCoB cermet was coupled with ZrO2, which had a lower hardness, the MoCoB cermet showed the highest friction coefficient (0.70) and wear rate 2.3×10–5 mm3/(N·m). The worn surface of MoCoB cermet was covered with a large of wear debris, and the wear degree was quite severe. Abrasive wear and adhesive wear were the main wear mechanisms. As MoCoB cermet slid against with Al2O3 ball, some abrasive debris could be detected on the MoCoB worn surface, and the tribo-film with fatigue cracks could be found as well. The main wear mechanisms were conceived to be adhesive wear. For MoCoB/Si3N4 tribo-pair, the MoCoB cermet could exhibit excellent wear-resistant property, of which the wear rate was as low as 1.6×10–6 mm3/(N·m), and the wear mechanism was dominated by slight abrasive wear. It was found that a layer of SiO2 oxide layer could be generated on the surface of the Si3N4 ball, which could play a good anti-friction and wear-resistant effect. When MoCoB cermet was coupled with a high hardness value of SiC, the tribo-oxidation products generated, which was caused by the tribo-oxidation effect on the MoCoB worn surface could reduce the friction effect. The friction coefficient was as low as 0.48. The main wear mechanisms were oxidative wear and fatigue wear.

     

/

返回文章
返回