ISSN   1004-0595

CN  62-1224/O4

高级检索
柏宗意, 韩一鸣, 栗心明, 李维民, 张建军. 点接触滑动-往复自旋运动润滑成膜规律研究[J]. 摩擦学学报(中英文), 2024, 44(6): 1−12. doi: 10.16078/j.tribology.2023022
引用本文: 柏宗意, 韩一鸣, 栗心明, 李维民, 张建军. 点接触滑动-往复自旋运动润滑成膜规律研究[J]. 摩擦学学报(中英文), 2024, 44(6): 1−12. doi: 10.16078/j.tribology.2023022
BAI Zongyi, HAN Yiming, LI Xinming, LI Weimin, ZHANG Jianjun. The Film Formation Law of Point Contact Sliding-Reciprocating Spin Motion Lubrication[J]. Tribology, 2024, 44(6): 1−12. doi: 10.16078/j.tribology.2023022
Citation: BAI Zongyi, HAN Yiming, LI Xinming, LI Weimin, ZHANG Jianjun. The Film Formation Law of Point Contact Sliding-Reciprocating Spin Motion Lubrication[J]. Tribology, 2024, 44(6): 1−12. doi: 10.16078/j.tribology.2023022

点接触滑动-往复自旋运动润滑成膜规律研究

The Film Formation Law of Point Contact Sliding-Reciprocating Spin Motion Lubrication

  • 摘要: 为模拟滚动轴承中常见的自旋工况,设计开发了1种可分别控制滑动速度和自旋速度的点接触光弹流滑动-往复自旋试验装置. 采用新开发的装置对带有自旋的钢球-玻璃盘接触副形成的弹性流体动力润滑油膜形状、厚度等进行试验研究,考察了运动学参数与供油条件对点接触自旋运动膜厚分布的影响,针对非稳态工况中的滑动-往复自旋复合运动进行了试验研究,对接触区油池分布以及供油状况进行了fluent两相流仿真. 结果表明,设计的试验装置可精确模拟接触副滑动-往复自旋复合运动,并实现了对该条件下的油膜分布可视化研究. 随着钢球自旋角速度增大,经典的马蹄形相对卷吸中心线的对称性就会消失,自旋速度越大,非对称性越明显,载荷越大,最小油膜厚度越小. 在非稳态运动过程中,最大自旋角速度时刻的油膜厚度低于稳态条件下相同角速度的油膜厚度;增大钢球往复自旋运动频率,对应时刻的油膜厚度变化减小. 往复自旋运动大大缩小了乏油工况下接触区入口距离,与仿真结果一致.

     

    Abstract:
    Rolling bearing is a key basic component in many mechanical equipments, such as high speed railroad, heavy duty weapon and many other high-end equipments have the demand of rolling bearing. In the actual use of working conditions, with the improvement of mechanical equipment precision and speed, the rolling bearing performance requirements are also higher and higher. Rolling bearings in the actual use of the process is usually in the unsteady state conditions, unsteady state movement may lead to contact area lubricant film collapse, compared with the steady state conditions, rolling bearings in unsteady state conditions are more likely to lubrication failure, thus reducing the rolling bearing operation precision and service life, and observation of the contact area film thickness can reflect the lubrication state of the rolling bearings, bearings in the actual use of the working conditions of the distribution of lubricating oil and change. The distribution and change of the lubricant in the bearing under the actual operating conditions have an important influence on the stable operation and life of the rolling bearing, therefore, the observation of the change of the oil film morphology of the bearing under the real operating conditions is of great significance.
    A rolling body rotates around the contact normal as it rolls. This rotational motion is called spin motion. The spin torque generated by the spin motion causes wear on the inner and outer rings of the bearing. Therefore, the study of elastic flow lubrication considering spin is of great importance. In order to simulate the common spin conditions in rolling bearings, a point contact elastohydrodynamic sliding-reciprocating spin experimental device that can precisely control the sliding speed and spin speed respectively is designed and developed. Ball-disc contact optical interference test is mostly used for lubrication performance and mechanism analysis because it is easy to change the kinematic parameters and observe the dynamic evolution of the oil film in the contact area. The effects of kinematic parameters and oil supply conditions on the film thickness distribution of point contact spin motion were investigated, and experiments were conducted for non-stationary conditions: sliding-reciprocating spin complex motion. The results indicated that the designed experimental device could accurately simulate the sliding reciprocating spin composite motion of the contact pair, and achieve visualization research on the oil film distribution under this condition. As the spin velocity of the steel ball increased, the symmetry of the classical horseshoe shape relative to the suction centerline disappeared. The higher the spin velocity, the more obvious the asymmetry, the greater the load, and the smaller the minimum oil film thickness. Under the unsteady-state, the oil film thickness at the moment of maximum spin velocity was lower than that at the same angular velocity under steady-state conditions; Increasing the frequency of reciprocating spin motion of the steel ball reduced the change in oil film thickness at the corresponding time. The reciprocating spin motion greatly reduced the inlet distance of the contact zone under the condition of oil shortage, which was consistent with the simulation results. In this paper, the study of different kinematic parameters and oil supply conditions on the rolling bearing spin condition was enlightened, which could help the stable movement of rolling bearings under the actual use of working conditions, improve the operating accuracy and service life of rolling bearings, and promote the further development of the theory of rolling bearing lubrication.

     

/

返回文章
返回